« previous next »
Pages: [1]   Go Down

Author Topic: TJ Rear Main Seal (RMS)  (Read 2858 times)

Offline Coqui

  • Honorary Member
  • Trail Queen
  • ***
  • Posts: 88
TJ Rear Main Seal (RMS)
« on: May 30, 2015, 11:54:14 PM »
Greetings Everyone,

Been out of the loop busy attending night school the last several months - hopeful to go wheel with you guys in the near future. Last October is switched to Royal Purple (RP) 10w30 for my TJ....the minor RMS leak grew larger and larger over time. So this past Memorial Day I tackled to project and swapped it out. Now the RMS leak is even worst...go figure. I've check the valve cover and oil filter area with no leaks - it's very apperant oil is seeping from RMS. Refilled with RP high mileage 10w30 oil and WIX oil filter.

I did noticed the RMS cap had two serious scratches on it....not sure if that would cause oil seepage.

Looking for suggestion and or POC information for a mechanic in the area.

Cheers!
David P.

« Last Edit: May 30, 2015, 11:58:54 PM by Coqui »
Logged
05’ Jeep Wrangler (TJ) Sport, IL6, AEM Brute Force Air Intake, Rough Country 4” Suspension Lift, Tom Wood's Custom Rear Drive Shaft, Advance Adapters SYE, 33” Goodyear Dura Trac w/15” Black Rock Rims, Banks Monster Exhaust.

Offline toreadorranger

  • Paid Members
  • Mudd Hog
  • ***
  • Posts: 235
Re: TJ Rear Main Seal (RMS)
« Reply #1 on: May 31, 2015, 06:08:44 PM »
So the Rear main seal you just replaced is leaking even worse?
Logged

Offline Coqui

  • Honorary Member
  • Trail Queen
  • ***
  • Posts: 88
Re: TJ Rear Main Seal (RMS)
« Reply #2 on: May 31, 2015, 07:19:46 PM »
Yes I would say slightly worst.
Logged
05’ Jeep Wrangler (TJ) Sport, IL6, AEM Brute Force Air Intake, Rough Country 4” Suspension Lift, Tom Wood's Custom Rear Drive Shaft, Advance Adapters SYE, 33” Goodyear Dura Trac w/15” Black Rock Rims, Banks Monster Exhaust.

Offline calvynandhobbs

  • Honorary Member
  • Trail Master
  • ***
  • Posts: 3087
Re: TJ Rear Main Seal (RMS)
« Reply #3 on: May 31, 2015, 09:39:49 PM »
They can be finicky when putting back together. I've only had to change one RMS and that was on my CJ7. Mine did the same thing. I got a friend to help the 2nd time just to make sure the pan was aligned correctly. It's just awkward putting everything back in and making sure it aligns correctly.
Logged
1994 YJ on 37s

Offline DirtyJeep92

  • Paid Members
  • Rock Crawler
  • ***
  • Posts: 438
  • 96 XJ HP44/9" 37s chopped caged.
Re: TJ Rear Main Seal (RMS)
« Reply #4 on: June 01, 2015, 02:17:27 AM »
Did your new seal come with a new wear sleeve?
Logged
ED 2

Offline Coqui

  • Honorary Member
  • Trail Queen
  • ***
  • Posts: 88
Re: TJ Rear Main Seal (RMS)
« Reply #5 on: June 01, 2015, 02:21:40 AM »
Nope - no wear sleeve.
Logged
05’ Jeep Wrangler (TJ) Sport, IL6, AEM Brute Force Air Intake, Rough Country 4” Suspension Lift, Tom Wood's Custom Rear Drive Shaft, Advance Adapters SYE, 33” Goodyear Dura Trac w/15” Black Rock Rims, Banks Monster Exhaust.

Offline DirtyJeep92

  • Paid Members
  • Rock Crawler
  • ***
  • Posts: 438
  • 96 XJ HP44/9" 37s chopped caged.
Re: TJ Rear Main Seal (RMS)
« Reply #6 on: June 08, 2015, 11:42:38 AM »
Usually most rear man seals come with a sleeve that slides over the crankshaft creating a new surface for the seal to ride on
Logged
ED 2

Offline skibum

  • Paid Members
  • Trail Master
  • ***
  • Posts: 869
Re: TJ Rear Main Seal (RMS)
« Reply #7 on: June 08, 2015, 12:45:24 PM »
I have seen a sleave for a front crank seal but never for a rear main oil seal. You will have to pull it apart again and inspect crank shaft for any scoring or scratches. Even small scratches will cause a leak and can damage new seal quickly. Some small scratches can be sanded with fine emery paper then followed with krokiss cloth. Its a time consuming job and must be done correctly or will leak. If u dont feel confident doing this then highly recomend you pay a shop to do it. Then if it is still leaking then its there problem.
Logged
09 Rubi 4Dr,Compleat Heavy Duty Polly Performance skid plate system,Kilby Evap Relocation kit,Rampage front bumper,Swaybar motor flip,Clayton 3.5in lift w/steering corection kit,35in GY MTR's on 15in MB Wheels,Ace Enginering Rear Bumper W/Tire carrier,Prorock D44 Front axel,5.13s,cromo rear shafts

Offline Coqui

  • Honorary Member
  • Trail Queen
  • ***
  • Posts: 88
Re: TJ Rear Main Seal (RMS)
« Reply #8 on: June 13, 2015, 04:27:25 AM »
Thanks for the feedback - going to dig into it to verify the oil pan gasket stayed in place correctly.
Logged
05’ Jeep Wrangler (TJ) Sport, IL6, AEM Brute Force Air Intake, Rough Country 4” Suspension Lift, Tom Wood's Custom Rear Drive Shaft, Advance Adapters SYE, 33” Goodyear Dura Trac w/15” Black Rock Rims, Banks Monster Exhaust.
Pages: [1]   Go Up
« previous next »